Development and standardization of processing technique for ready

Scientific Reports volume 13, Article number: 185 (2023) Cite this article

929 Accesses

1 Citations

1 Altmetric

Metrics details

Black carrots are rich in bio-actives but underutilized owing to their short-term availability and perishable nature. Traditionally, black carrots have been used for the preparation of Kanji—a fermented non-dairy beverage prepared using natural fermentation by lactic acid bacteria and a few spices. This plant-based probiotic beverage has high antioxidant properties but there is a risk of contamination with pathogens due to uncontrolled fermentation during storage. To enhance the availability of this nutritious beverage throughout the year and to ensure the microbiological safety of the traditional fermented product, the present study was planned to optimize the process for controlled fermentation using freeze-dried lactic acid bacterial (LAB) culture and refractance window-dried black carrot powder. The physicochemical and microbiological profiles of LAB-fermented Kanji were analysed. The dried Kanji mix can be reconstituted into naturally fermented probiotic beverage with unique flavour and aroma along with ensured microbiological safety and enhanced commercial value.

Consumer demand for functional non-dairy products has risen and probiotics are used to create ready-to-drink drinks made from fruits and vegetables. Fermented foods with plant origin have been evaluated as vectors for administration of probiotic lactic acid bacterial cultures following the proficiency of the production of vegetable based fermented products via lactic acid bacteria1. Further, the likeness of consumers towards fresh like, minimally processed, highly nutritive, health-promoting and thirst quenching ready-to-serve beverages is increasing2. Traditionally, food fermentation using lactic acid bacteria is being performed since time immemorial and the utilization of functional starter cultures improve the functional quality of the products.

Black carrots (Daucus carota subsp. sativus) are in greater consumer's interest due to their rich antioxidant, anthocyanins content and other phytochemicals content3,4. However, poor post-harvest management and delayed marketing significantly alter the concentrations of its bioactive compounds5,6. Fermented and probiotic black carrot beverage is a healthy option due to its high antioxidant activity aiding against lifestyle diseases and chronic ailments properties including improvement of lactose metabolism, prevention of gut infections, enhancement of immunity, reduction in serum cholesterol level, stimulation in calcium absorption, synthesis of vitamins (vitamin-B, folic acid and nicotinic acid), enhancement of protein digestibility and counteraction against ill effects of food borne pathogens7.

Traditional lactic acid fermented ready-to-serve black carrot beverage, commonly known as ‘Kanji’ and is helpful in treatment of indigestion, loss of appetite and liver disorders. During traditional fermentation of black carrots, natural lactic acid fermentation imparts probiotic properties to the minimally processed beverages but risk of contamination with pathogens Cronobacter sakazakii, Klebsiella pneumonia and Enterobacter hormaechei has been detected in the stored naturally fermented black carrot beverage ‘Kanji’8. Hence, the need arises to ensure the microbiological safety of the traditional fermented product by using controlled fermentation techniques and aseptic handling for the large-scale production.

Controlled fermentation conditions utilizing pure function lactic acid starter culture result in enhanced control over the fermentation process and product uniformity. However, the high nutritional value of fermented Kanji lends itself to the growth of several spoilage microbes during storage through longer duration. As a result, it is not available for consumption during off seasons. The availability of this nutritional beverage can be enhanced muti-fold if it is made shelf stable which is possible through advanced drying techniques. Although many techniques for drying of fruits/ vegetables are in practice but some are incapable of preserving the bioactive compounds like open sun drying, solar drying and hot-air drying, etc.9,10. While the drying techniques that can preserve bioactives are quite expensive like freeze drying.

Refractance window drying (RWD) is a new and revolutionary process developed by MCD Technologies Inc (Tacoma, Washington, USA)11,12. The RWD approach has been shown to be effective for drying heat-sensitive materials such as liquids and purees into powders, flakes, or sheets13. This drying technique outperforms the conventional method due to reduced drying temperature, drying time, energy consumption, and greater quality retention. The researchers have found that results of RW dried potato14, carrot15, tomato16, goldenberry17 and aloe vera18 had maximum quality retention. Considering the advantage of RWD technique, the present study was planned to dry black carrot puree using RW dryer then fermented with freeze dried LAB to produce reconstituted Kanji.

Fresh black carrots (cv. Punjab Black Beauty) were harvested in February were obtained from the Department of Vegetable Science at the Punjab Agricultural University (PAU) in Ludhiana, Punjab, India. Before use, black carrots were precooled in a walk-in cold room at 10 °C and 85% relative humidity. Experiments were carried out at the laboratories of Department of Processing and Food Engineering, Punjab Agricultural University (PAU), Ludhiana, India to achieve the desired result. For experimentation, the precooled black carrots were washed, peeled using hand peeler and top of carrots were removed. The peeled black carrots were treated by dipping in sodium hydroxide (NaOH) solution at three different concentrations (i.e., 0, 1 and 2% v/v). The treated samples were then processed into puree using pulper. The freshly prepared puree was dried using batch type pilot scale refractance.

The RSM was used to assess the effect of two independent variables, namely water temperature (x1) and NaOH concentration (x2), on several quality metrics such as colour change, total flavonoid content, total phenolic content, and rehydration ratio. Experiments were conducted in duplicate. Based on a two-factor three-level miscellaneous experimental design, thirteen experimental runs were developed. The experiment was randomized, with the centre point repeated five times. ANOVA and regression surface analysis were utilised to describe the statistical significance of model variables and to fit a regression connection appropriate to the experimental design. The terms that were statistically significant (p < 0.05) were included in the final model19. The following is the generalised polynomial model developed to predict response variables based on independent factors:

where yk is the model's projected response value; β0, βi, βii, and βij are constants, regression coefficients for linear, quadratic, and interaction effects factors, and xi is the coded independent variable. The Miscellaneous 3-Level Factorial in Design expert programme (Version 7.0.0) was used for the experimental design and data analysis (Stat-Ease Inc., Minneapolis, MN, USA). The response surface and contour plots were created for various interactions. These three-dimensional surfaces might give a precise geometrical representation as well as important information on the system's behaviour within the experimental design. The RW-dried black powder was tuned to determine the quantities of independent components that would result in the least degree of colour change and the highest total flavonoid content, total phenolic content and rehydration ratio.

The optimized dried sample obtained based on minimum colour change and maximum total flavonoid content, total phenolic content and rehydration ratio was used in preparation of probiotic black carrot drink (Kanji).

Functional Lactic Acid Bacteria as starter culture for preparation of traditional drink Kanji from dried black carrots powder were procured from Department of Microbiology, PAU, Ludhiana, India. A 24-h cultivation of consortium of ten LAB in the MRS broth was carried out at 37 °C, for obtaining a cell density of 107 cfu/ml (before lyophilization). Cells were extracted by centrifuging at 11,000 × g for 5 min at 4 °C, followed by three washes with sterile distilled water. The supernatant was then discarded, and the captured cells were re-suspended in 100 mL of medium (final viable counts in the range of 7–8 log CFU/mL). Before lyophilization, all re-suspended cells were frozen at 20 °C. The frozen suspensions were freeze-dried for 48 h (temperature − 40 ± 2 °C; vacuum pressure 10−1 torr) using a bench-top lyophilizer (Modulyo bench top freeze dryer, Edwards, Burgess Hill, UK). The retention of the microbial load in the freeze-dried culture (5–8% w/v) was using standard protocol. Lactic acid bacterial count equivalent to 7.9–8.96 log cfu/g makes an ideal starter culture for production of ready-to-use lactic acid fermented Kanji.

The mix was prepared using different loads of freeze-dried LAB and different concentrations of optimized RW-dried black carrot powder along with the standard spices to attain the desired Kanji formulation upon reconstitution. The reconstituted Kanji formulations were analysed for quality using standard procedures. The Kanji mix was optimized using RSM based upon the responses of designed experiment. The quality of reconstituted Kanji drink prepared under optimized conditions was compared with control Kanji drink prepared by traditional method using fresh black carrots to determine the acceptability of the developed ready to use Kanji mix.

Rehydration standardization of RW-dried black carrot powder in water for getting the same desired traditional Kanji beverage taste was done using different proportions of powder with water 10:50, 10:60 and 10:70, on the basis of physicochemical characteristics, microbiological analysis and sensory evaluation.

The fermentation of traditional Kanji beverage was carried out by autochthonous lactic acid bacteria inherent to black carrots, by extracting the carrot juice and shredded carrots and diluting it with three volumes of boiled and then cooled at ambient temperature water and allowed to ferment at room temperature (25 ± 2 °C) for 5 days with the addition of salt and rye at 1.5%. Kanji beverage preparation through controlled fermentation was carried with diluted beverage pasteurized at 82 °C for 10–15 s using pasteurizer (Dairy Tech, Maharashtra, India) and inoculating with 8% (v/v) of actively grown functional starter inoculum (108 cfu mL−1) of functional lactic acid bacterial consortium. Other spices: Pink Rock Salt (1.5%), Rye (1.5%) were sterilized before use in the mix. A portion of pasteurized beverage was kept as control of the fermentation process. The inoculated beverage was incubated at 37 °C for 24–36 h (conditions determined in preliminary tests). Samples were aseptically drawn and analysed for microbiological and physicochemical parameters.

For RW-dried black carrot powder quality was measured on the basis of colour change, total flavonoid content, total phenolic content, and rehydration ratio. While quality for LAB fermented Kanji beverage and traditional Kanji beverage was measured on the basis of titratable acidity, pH, Brix-Acid ratio, total sugars, total reducing sugars, antioxidant activity, total flavonoid content, total phenol content, total carotenoids, ascorbic acid content. The following methods of each parameter have been explained below in various subheadings:

A portable colorimeter (Konica Minolta Sensing Inc, Japan) was used to determine the colour of the samples20. The colour is defined by the tristimulus values L, a, and b. The colour change was determined using the following relationship21:

where, Lo, ao and bo represent the respective readings of fresh black carrot puree.

At 95 °C, the samples were submerged in water at a 1:15 ratio for 20 min. The excess water was removed using the Whatman paper no. 1, and the samples were weighed22.

The pH of rehydrated Kanji beverage was evaluated using a digital pH metre (type 101, Electronic Corporation of India Limited, Hyderabad).

Total soluble solids (TSS) in rehydrated carrot juice and beverage were examined by Erma hand Refractometer of 0–32°Brix (UNICO). The refractometer was calibrated at zero line on the scale by placing a drop of distilled water on clean and dry prism at 20 °C. The TSS value of samples was determined by adding a drop of sample on the clean prism and reading the clear line of demarcation on the scale.

Titratable acidity, expressed as %Lactic acid, was estimated following the procedure of Helrich23. Known quantity of beverage was used and few drops of 1% Phenolphthalein solution as indicator were added. Titration of solution was performed against standardized 0.1 N Sodium Hydroxide (NaOH) to the pink coloured end point persisted for 15 s.

Brix-Acid ratio was calculated by dividing Total soluble solids value with total acidity of the rehydrated juice and beverage to evaluate the ripeness of carrots.

Total sugars were determined using the DuBois et al.24 technique. In the test tubes, measured volumes of 0.1–0.5 ml of sample/standard were placed, and the volume was increased to 1 mL using distilled water. Each test tube received 1 ml of a 5 percent phenol solution, which was well shaken. Following that, 5 ml of strong sulphuric acid was added. For the best appearance of yellow colouring, sulfuric acid was poured straight into the centre of the test tube and the temperature was raised to 70 °C. The test tubes were left at room temperature for 10 min before being cooled. The absorbance of the produced stable yellow-orange colour was measured at 490 nm with a spectrophotometer (Bausch & Laumb Spectronic-20) against a reagent blank. The total soluble sugars were determined using glucose as the standard curve (20–100 mg mL−1).

Miller25 method was used for the quantification of total reducing sugars in the samples. 3 mL of the sample and 3 mL of DNS reagent were added in the test tube and kept in the hot water bath at 60 °C for 15 min. 1 ml Rochelle salt solution was then added to the tubes and were allowed to cool down. The absorbance was taken at 575 nm using spectrophotometer (Bausch & Laumb Spectronic-20). The standard curve was used to calculate the concentration of reducing sugars (20–100 g mL−1).

DPPH technique given by de Ancos et al.26 was used to calculate the percent antioxidant activity. Aliquots of 0.1 ml sample were collected in a test tube for estimation. It was placed in the dark for 45 min after the addition of 3.9 mL DPPH solution (1 M DPPH). The discoloration in the solution was measured with a Bausch & Laumb Spectronic-20 at 515 nm.

Total flavonoid content was evaluated by the method given by Carvalho and Clemente27 with small modifications. In a test tube, 0.2 ml of each standard or sample was placed, then 1 mL of methanol was added. 1 ml of methanol was used to make the blank. Each test tube received 0.1 mL of a 10% aluminium nitrate solution. After that, 0.1 mL of 1 M potassium acetate was added, followed by 4.6 ml of distilled water. The materials were properly combined and left at room temperature for 45 min. The absorbance was measured at 415 nm against a methanol reference blank. The total flavonoid content (mg of Quercetin equivalents) was estimated using the Quercetin standard curve.

The total phenolic content was determined using the technique of Slinkard and Singleton28, with minor modifications. 0.2 ml of each sample/standard was placed in a test tube, and a volume of 1 ml was produced with methanol. The materials were well mixed after 2 ml of Folin-ciocalteu reagent was added, then 2 mL of 15% Na2CO3 solution was added after four minutes. The mixture was maintained at room temperature for two hours. The absorbance of each sample was taken at 760 nm against a reference was measured at 760 nm against a blank prepared in the similar way as of the samples without the addition of sample or standard. Total phenolic content (mg Gallic acid equivalents) was calculated from standard curve of Gallic acid.

The titrimetric method with 2, 6- Dichlorophenol Indophenol dye was used in the estimation of ascorbic acid29. Measured volume of an aliquot (10 ml) was taken and 15 ml of oxalic acid solution (0.4%) was added followed by titration against standardized dye solution (0.04%) to a pink colour end point with 15 s of persistence.

Carotenoids extraction was based on the procedure described by Rodriguez-Amaya and Kimura30. 5 ml of each sample was homogenized using chilled acetone and filtered using a Büchner funnel. The technique was repeated until the residue and pigments were discoloured and transferred to petroleum ether; each fraction was rinsed with distilled water to remove all traces of acetone. After full extraction, the total carotenoids content of the isolated pigments was measured spectrophotometrically at 450 nm.

The viability of bacteria in rehydrated Kanji beverage was evaluated by standard plate count method. Bacterial plate count was recorded after 24–48 h at 37 °C on Man Ragosa Sharpe Agar (HiMedia Laboratories Pvt Ltd, Mumbai) for lactic acid bacterial count8.

The 30 ml LAB fermented Kanji beverages were placed separately in labelled plastic cups. These cups were kept at room temperature (28 ± 3 °C) inside cubical having daylight settings. Thirty panellists (15 male and 15 female) were recruited from staff and students at the University of Punjab Agricultural University. Drinking water was provided for subjects to rinse their mouth between two drinks and five minutes time was given between each drink. A semi-trained panel of judges evaluated the organoleptic properties of black carrot beverage based on appearance, taste, colour, aroma, body, flavour, astringency, and overall acceptability. The "Hedonic scale" of consumer acceptability was used to calculate product acceptance31.

The RW-dried black carrot powder was produced by adjusting two process variables, namely water temperature (70, 80, and 90 °C) and NaOH solution concentration (0, 1, and 2% v/v), and the method was adjusted based on the impacts on chosen responses (colour change, flavonoids, total phenolic content and rehydration ratio). Table 1 shows the analysis of variance for all responses, and three-dimensional response surface plots (Fig. 1) were created to show the influence of process factors on the response parameters of the RW-dried black carrot powder.

Effect of water temperature and NaOH concentration on quality parameters of dried black carrot.

Colour is a key quality factor that is used to assess the quality of any food product. As a result, changes in colour aid in identifying changes in product quality32. The colour change of dried black carrot ranged from 1.48 to 4.61. The maximum colour change was observed for samples pre-treated in 2%NaOH solution and dried at 90 °C water temperature whereas minimum was found for untreated samples dried at 70 °C. The linear term of water temperature and NaOH concentration had significant positive effect on colour change (p < 0.05). It was observed that with increase in NaOH concentration during pre-treatment of black carrot had increased the colour change in black carrot powder (Fig. 1). This was due to increase in ‘L’ value of carrot, hence increasing overall colour change value when compared with fresh produce. The rise in water temperature also resulted in an increase in colour change, which may be ascribed to an increase in ‘a’ value than the ‘b’ value of black carrot powder33. The increase in ‘a’ value has been reported in various foods owing to chemical reaction that occurs between amino acids and reducing sugars while processing at higher temperatures which generate brown colour and subsequent occurrence of Milliard's reaction34.

Flavonoids have been demonstrated to be helpful to human health due to their capacity to serve as free radical scavengers and oxidative potential-reducing agents, hence protecting against oxidative damage produced by hydroxyl groups35. The total flavonoid content of dried black carrot ranged from 5.97–10.75 mg/100 g dw. The minimum total flavonoid content was observed for samples pre-treated in 2%NaOH solution and dried at 90 °C water temperature whereas maximum was found for untreated samples dried at 70 °C. The linear term of water temperature had significant negative effect on total flavonoid content (p < 0.05). It was discovered that the total flavonoid content of black carrot powder decreased with an increase in water temperature (Fig. 1). This might be because higher temperatures caused partial lignin breakdown and thermal degradation of phenolic compounds36.

Total phenolic content of dried black carrot ranged from 22,876.40 to 23,444.30 mg/100gdw. The maximum colour change was observed for untreated samples dried at 70 °C minimum was found for samples whereas pre-treated in 2%NaOH solution and dried at 90 °C water temperature. The linear term of water temperature had significant negative effect on total phenolic content (p < 0.05). It was observed that with increase in water temperature of dryer decreased the total phenolic content in black carrot powder (Fig. 1). One such explanation for the decrease in overall phenolic content at high temperatures is the impact of heat on tannic compounds and the death of cells and their vacuoles, which causes phenolic compounds to attach to other compounds such as proteins or changes in their chemical structures18.

Rehydration ratio of dried black carrot ranged from 4.99 to 6.30. The minimum rehydration ratio was observed for samples pre-treated in 2%NaOH solution and dried at 90 °C water temperature whereas maximum was found for untreated samples dried at 70 °C. The linear term of water temperature had significant positive effect on rehydration ratio (p < 0.05). The rehydration ratio of black carrot powder was found to decrease with an increase in the water temperature of dryer. (Fig. 1). This can be owing to overheating of the product surface causing development of an impervious layer making it difficult for the dried product to rehydrate to its actual volume and shape33,37.

Using the numerical optimization technique, the optimum process conditions for black carrot powder was obtained by dipping black carrot in 0% NaOH solution followed by refractance window drying at water temperature of 70 °C. Black carrot powder produced under optimized condition predicted to have the highest value of total flavonoid content: 11.11 mg/100 g dw, total phenolic content: 23,493.50 mg/100g dw and rehydration ratio: 6.49 whereas the least possible colour change: 2.08 with overall desirability of 94.8%. The samples were further dried in bulk under the optimized process condition to produce black carrot powder for reconstituted Kanji beverage.

For the evaluation of the right reconstitution ratio of RW-dried black carrot powder for beverage formulation, the three proportions of powder with water i.e., 10:50, 10:60 and 10:70 were prepared and subjected to sensory evaluation. The sensory evaluation was carried out on a 9-point Hedonic scale. The score obtained from the panellists has been given in the Table 2. From the sensory scores, it is clearly observed that the 10:60 combination of RW-dried black carrot powder and water have shown better acceptability (7.8 ± 0.2) compared to other combinations.

Functional lactic acid bacterial inoculum concentration, containing the cell load of 107 cfu/ml was used as inoculum in developing lactic acid fermented Kanji beverage. The varied percentages of lyophilized inoculum concentration were taken (4–8% w/v) and incorporated in the standardized RW-dried Kanji beverage reconstituted (10:60) and fermented for 24 h at 37 °C to see the variation in cell load with respect to the lactic acid bacterial cell load in the fermented traditional beverage. The data obtained after enumeration studies in traditionally fermented and after freeze drying fermentation have been depicted in Table 3. Functional lactic acid bacterial count in RW-dried black carrot powder fermented with 7% (w/v) freeze-dried inoculum was in line with cell load in traditionally fermented Kanji beverage. Hence, a minimum of 7% (w/v) freeze-dried inoculum concentration is required that fulfils the requirements in traditionally fermented Kanji beverage.

The black carrot powder was reconstituted according to the standardization with water and fermented with standardized freeze-dried 7% (w/v) inoculum concentration with a cell load of 9.21 log cfu/ml at 37 °C for 28 h and fermentation kinetics was studied in terms of lactic acid bacterial growth during the fermentation, pH and total titratable acidity kinetics. The proliferation of lactic acid bacteria during fermentation can provide vital information about the properties of fermented Kanji beverage. Figure 2A depicts the change in the quantity of lactic acid bacteria. The bacteria adapted quickly in the reconstituted beverage, resulting in an increase in viability from the original fermentation. The number of lactic acid bacteria in the beverage rapidly grew within the first 24 h, which corresponds to the usual microbial development curve. After the first 24 h, the number of lactic acid bacteria decreased slightly and then stabilised. Also, Fig. 2A showed that Polynomial 3rd order model showed best fit model to describe increase in viability of bacteria with highest R2 value of 0.985. Costa et al.38 discovered that after 24 h of fermentation by L. casei NRRL B-442, the viability in pineapple juice reached 8.65 log cfu/ml. After the first 24 h, the build-up of significant lactic acid and other metabolites impeded the proliferation of lactic acid bacteria. In brief, RWD-dried black carrot powder reconstituted with water (10:60 ratio) is an appropriate substrate for probiotics and can be used as a nutritional media to enhance LAB development.

(A) The amount of microbial (lactic acid bacteria), (B) pH and total titratable acidity during LAB fermentation of Kanji beverage reconstituted at 10:60 concentration.

Figure 2B depicts the results of an investigation into the pH and titratable acidity dynamics of fermented beverages. Because of the increasing titratable acidity content, the pH fell during the fermentation. After 12 h of fermentation, the pH of the Kanji beverage was lower than 4.0, which was a threshold for inhibiting pathogenic and numerous septic bacteria38. In Fig. 2B, Polynomial 3rd order model showed best fit model to describe decrease in pH and increase in TA with respect to time, having highest R2 value of 0.955 and 0.994 for pH and TA, respectively. After 28 h of fermentation, the titratable acidity rose from 0.13 g/100 ml to 0.96 g/100 ml. A similar rise was observed during fermentation of rice-based beverage by Ghosh et al.39. The increasing concentration of organic acids produced by the lactic acid bacteria fermentation process, particularly the formation of lactic acid, might explain the variations in pH and titratable acidity7.

The total phenolic content, total flavonoid content and antioxidant capacity of fermented beverage after 24 h of fermentation as compared to the initial 0 h shown in the Table 4. Phytochemical concentrations rise after 24 h as compared to the first stage, indicating that LAB enhanced the phytochemical concentration of the beverage during the fermentation process. The higher amount of phytochemical concentrations in fermented beverage might be ascribed to LAB's capacity to create hydrolytic enzymes, which hydrolyzed the complex phytochemicals into simpler forms31,40. The total phenolic content of the 24 h fermented samples increased from 32.73 ± 0.61 mg (at 0 h) to 41.84 ± 0.10 mg GAE/ml. Total phenolic content are widespread secondary metabolites of plants that are involved in plant defence against UV radiation or pathogen aggressiveness. Epidemiological research and accompanying meta-analyses clearly suggest that long-term intake of plant polyphenol-rich diets protects against the development of malignancies, cardiovascular illnesses, diabetes, osteoporosis, and neurological disorders41. Furthermore, the LAB-fermented Kanji beverage's lower pH (3.76) stabilises the polyphenols as they auto-oxidize with increasing pH8.

Antioxidant activity (%), as presented in the Table 4, showed an increase from 0 to 24 h of fermentation. Kwaw et al.42 discovered a relationship between polyphenolic and antioxidant activities. The findings suggested that processing of fermented beverages enhanced the total phenolic content and total flavonoid content, resulting in higher antioxidant activity in the developed product.

The physicochemical parameters were slightly varied in the fermented Kanji beverage prepared by reconstituted as compared to the standard traditional fermented Kanji beverage as shown in the Table 5. Despite higher pH and less acidification was observed for the reconstituted one when compared to the traditional one, there is no significant differences (p > 0.05) observed for pH and titratable acidity.

The total phenolic content, total flavonoid content and antioxidant activity values of both the traditional and rehydrated Kanji beverage are in the same line. Tangüler43 found similar results in the shalgam powder production from fermented shalgam (a traditional Turkish beverage). Shalgam powder reconstituted at 3.2% has similar physicochemical properties as in the traditional shalgam beverage in terms of pH, titratable acidity, total solids, polyphenols, flavonoids content and antioxidant capacity. Thus, Kanji beverage prepared from reconstitution of RWD-dried powder can be a good alternative with increased shelf-life to obtain functional benefits of Kanji beverage throughout the year.

The mean acceptability scores of reconstituted Kanji beverage and conventional beverage are shown in Fig. 3. For the qualities taste and general acceptability, the reconstituted was marginally better accepted (p < 0.5) than the traditional. There were no significant changes in colour, astringency, or aroma across the samples (p > 0.05). The reconstituted beverage's mean acceptance ratings were about (7.9) on the hedonic scale, which corresponds to "liked very much," showing strong acceptance of the sample, which was also seen for the conventional one. Santos et al.44 investigated freeze dried yoghurts and discovered moisture, total solids, and lactic acid percentages of 79.44, 20.86, and 0.92, respectively, as well as pH of 4.37 and diacetyl of 11.13 mg/50 mL in the reconstituted product (5 g/20 °C). These researchers received ratings of 6.67, 6.82, 6.77, and 6.45 on a 9-point hedonic scale for the rehydrated product's appearance, flavour, taste, texture, and overall approval, respectively.

Overall acceptance score of traditional Kanji beverage and LAB fermentation of Kanji beverage reconstituted at 10:60 concentration.

Plant-based probiotic beverages have been witnessing a rise in demand as well as acceptance in the diet of consumers owing to consumer demand for functional non-dairy products. Fermented black carrot beverage ‘Kanji’ is a traditional drink that has been prepared in Indian household since ages. This beverage is highly rich in bioactives and flavonoids, having considerable health benefits to consumers. In this study an effort has been made to prepare a nutrition-rich beverage that can be made available in ready to use format for consumption throughout the year by using advanced drying technologies. The study focused on development and standardization of bioprocess technology for the shelf-stable Kanji mix incorporating freeze-dried lactic acid bacterial culture in RW-dried black carrot powder and spices. Black carrot powder was obtained by dipping black carrot in 0% NaOH solution and drying puree at water temperature of 70 °C in RW dryer. The Kanji mix was reconstituted with water at concentration of 10:60 and subjected to controlled fermentation for 24 h. The reconstituted beverage was found to be microbiologically safe with acceptability equivalent to traditionally prepared Kanji beverage. It was concluded that using this technique similar LAB fermented drinks can be prepared as traditional method of fermentation is not controlled, causing an increase in bacterial count and making the drink unfit for consumption.

The datasets generated during and/or analysed during the current study are available from the corresponding author on reasonable request.

Tamang, J. P. et al. Fermented foods as a dietary source of live organisms. Front. Microbiol. 9, 1785 (2018).

Article Google Scholar

Kearney, J. Food consumption trends and drivers. Philos. Trans. R. Soc. B 365, 2793–2807 (2010).

Article Google Scholar

Garba, U., Kaur, S., Gurumayum, S. & Rasane, P. Effect of hot water blanching time and drying temperature on the thin layer drying kinetics of and anthocyanin degradation in black carrot (Daucus carota L.) Shreds. Food Technol. Biotechnol. 53, 324–330 (2015).

Article CAS Google Scholar

Nath, P., Dukare, A., Kumar, S., Kale, S. & Kannaujia, P. Black carrot (Daucus carota subsp. sativus) anthocyanin-infused potato chips: Effect on bioactive composition, color attributes, cooking quality, and microbial stability. J. Food Process. Preserv. 46, e16180 (2022).

Article CAS Google Scholar

Algarra, M. et al. Anthocyanin profile and antioxidant capacity of black carrots (Daucus carota L. ssp. sativus var. atrorubens Alef.) from Cuevas Bajas, Spain. J. Food Compos. Anal. 33, 71–76 (2014).

Article CAS Google Scholar

Singh, J., Kaur, S. & Rasane, P. Evaluation of the nutritional and quality characteristics of black carrot fortified instant noodles. Curr. Nutr. Food Sci. 14, 442–449 (2017).

Article Google Scholar

Lamba, J., Goomer, S. & Saxena, S. K. Study the lactic acid bacteria content in traditional fermented Indian drink: Kanji. Int. J. Gastron Food Sci. 16, 100143 (2019).

Article Google Scholar

Sharma, C. & Kaur, S. Physicochemical and microbiological evaluation of antioxidant-rich traditional black carrot beverage: Kanji. Bull. Natl. Res. Cent. 45, 143 (2021).

Article Google Scholar

Zalpouri, R., Singh, M., Kaur, P. & Singh, S. Refractance window drying–a revisit on energy consumption and quality of dried bio-origin products. Food Eng. Rev. 14, 257–270 (2022).

Article CAS Google Scholar

Kaur, D., Singh, M., Zalpouri, R. & Singh, I. Osmotic dehydration of fruits using unconventional natural sweeteners and non-thermal-assisted technologies: A review. J. Food Process. Preserv. https://doi.org/10.1111/jfpp.16890 (2022).

Article Google Scholar

Kumar, N. et al. Refractance Window TM -Drying vs. other drying methods and effect of different process parameters on quality of foods: A comprehensive review of trends and technological developments. Futur. Foods 3, 100024 (2021).

Article Google Scholar

Raghavi, L. M., Moses, J. A. & Anandharamakrishnan, C. Refractance window drying of foods: A review. J. Food Eng. 222, 267–275 (2018).

Article Google Scholar

Zalpouri, R., Kaur, P. & Sain, M. Refractive window drying- A better approach to preserve the visual appearance of dried products. Pantnagar J. Res. 18, 90–94 (2020).

Google Scholar

Zalpouri, R., Kaur, P. & Kaur, A. Influence of developed refractance based drying method on physical parameter of potato flakes. Int. J. Chem. Stud. 8, 2833–2838 (2020).

Article Google Scholar

Hernández-Santos, B. et al. Evaluation of physical and chemical properties of carrots dried by Refractance Window drying. Drying Technol. 34, 1414–1422 (2016).

Article Google Scholar

Durigon, A., de Souza, P. G., Carciofi, B. A. M. & Laurindo, J. B. Cast-tape drying of tomato juice for the production of powdered tomato. Food Bioprod. Process. 100, 145–155 (2016).

Article CAS Google Scholar

Puente, L. et al. Refractance Window drying of goldenberry (Physalis peruviana L.) pulp: A comparison of quality characteristics with respect to other drying techniques. LWT Food Sci. Technol. 131, 109772 (2020).

Article CAS Google Scholar

Seyfi, A., Asl, A. R. & Motevali, A. Comparison of the energy and pollution parameters in solar refractance window (photovoltaic-thermal), conventional refractance window, and hot air dryer. Sol. Energy https://doi.org/10.1016/j.solener.2021.05.094 (2021).

Article Google Scholar

Kaur, P., Zalpouri, R., Singh, M. & Verma, S. Process optimization for dehydration of shelled peas by osmosis and three-stage convective drying for enhanced quality. J. Food Process. Preserv. 44, e14983 (2020).

Article CAS Google Scholar

Kalsi, B. S., Singh, S. & Alam, M. S. Influence of ultrasound processing on the quality of guava juice. J. Food Process. Eng. https://doi.org/10.1111/JFPE.14163 (2022).

Article Google Scholar

Kaur, P., Mahal, A. & Kumar, N. Optimization of spray drying conditions for production of aloe-vera powder. Chem. Sci. Rev. Lett. 6, 525–532 (2017).

CAS Google Scholar

Puttongsiri, T., Choosakul, N. & Sakulwilaingam, D. Moisture content and physical properties of instant mashed potato. Int. Conf. Nutr. Food Sci. 39, 92–95 (2012).

Google Scholar

Helrich, K. Official Methods of Analysis of the Association of Official Analytical Chemists (Association of official analytical chemists, 1990).

Google Scholar

DuBois, M., Gilles, K. A., Hamilton, J. K., Rebers, P. A. & Smith, F. Colorimetric method for determination of sugars and related substances. Anal. Chem. 28, 350–356 (1956).

Article CAS Google Scholar

Miller, G. L. Use of dinitrosalicylic acid reagent for determination of reducing sugar. Anal. Chem. 31, 426–428 (1959).

Article CAS Google Scholar

de Ancos, B., Sgroppo, S., Plaza, L. & Pilar Cano, M. Possible nutritional and health-related value promotion in orange juice preserved by high-pressure treatment. J. Sci. Food Agric. 82, 790–796 (2002).

Article Google Scholar

de Carvalho, P. T. & Clemente, E. The influence of the broccoli (Brassica oleracea var. itálica) fill weight on postharvest quality. Food Sci. Technol. SciELO Brasil 24, 646–651 (2004).

Article Google Scholar

Slinkard, K. & Singleton, V. L. Total phenol analysis: Automation and comparison with manual methods. Am. J. Enol. Vitic. 28, 49 (1977).

CAS Google Scholar

Ranganna, S. Handbook of Analysis and Quality Control for Fruit and Vegetable Products (Tata McGraw-Hill Education, 1986).

Google Scholar

Rodriguez-Amaya, D. & Kimura, M. HarvestPlus handbook for carotenoid analysis. Washington: International Food Policy Research Institute (IFPRI) 2, (2004).

Adebo, O. A. & Medina-Meza, I. G. Impact of Fermentation on the phenolic compounds and antioxidant activity of whole cereal grains: A mini review. Molecules 25, 927 (2020).

Article CAS Google Scholar

Aggarwal, K., Singh, M. & Zalpouri, R. Effect of treatment and drying method (Solar and convective) on physico-chemical quality of dried moringa leaves. Int. J. Agric. Sci. 17, 228–233 (2021).

Google Scholar

Zalpouri, R., Kaur, P., Kaur, A. & Sidhu, G. K. Comparative analysis of optimized physiochemical parameters of dried potato flakes obtained by refractive and convective drying techniques. J. Food Process Preserv. 45, e15077 (2021).

Article CAS Google Scholar

Tamanna, N. & Mahmood, N. Food Processing and maillard reaction products: Effect on human health and nutrition. Int. J. Food Sci. https://doi.org/10.1155/2015/526762 (2015).

Article Google Scholar

Potdar, P. P., Kaur, P., Zalpouri, R. & Ummat, V. Convective and pulsed microwave drying of lemongrass (Cymbopogon citratus) shreds: Kinetic modeling, retention of bio-actives, and oil yield. J. Food Process. Preserv. https://doi.org/10.1111/jfpp.16914 (2022).

Article Google Scholar

Hidar, N. et al. The impact of solar convective drying on kinetics, bioactive compounds and microstructure of stevia leaves. Renew Energy 161, 1176–1183 (2020).

Article CAS Google Scholar

Giri, S. K. & Prasad, S. Drying kinetics and rehydration characteristics of microwave-vacuum and convective hot-air dried mushrooms. J. Food Eng. 78, 512–521 (2007).

Article Google Scholar

Costa, M. G. M., Fonteles, T. V., de Jesus, A. L. T. & Rodrigues, S. Sonicated pineapple juice as substrate for L. casei cultivation for probiotic beverage development: Process optimisation and product stability. Food Chem. 139, 261–266 (2013).

Article CAS Google Scholar

Ghosh, K. et al. Role of probiotic Lactobacillus fermentum KKL1 in the preparation of a rice based fermented beverage. Bioresour. Technol. 188, 161–168 (2015).

Article CAS Google Scholar

Kaltsa, A., Papaliaga, D., Papaioannou, E. & Kotzekidou, P. Characteristics of oleuropeinolytic strains of Lactobacillus plantarum group and influence on phenolic compounds in table olives elaborated under reduced salt conditions. Food Microbiol. 48, 58–62 (2015).

Article CAS Google Scholar

Mutha, R. E., Tatiya, A. U. & Surana, S. J. Flavonoids as natural phenolic compounds and their role in therapeutics: An overview. Future J. Pharm. Sci. 7, 1–13 (2021).

Google Scholar

Kwaw, E. et al. Effect of lactobacillus strains on phenolic profile, color attributes and antioxidant activities of lactic-acid-fermented mulberry juice. Food Chem. 250, 148–154 (2018).

Article CAS Google Scholar

Tangüler, H. The effect of using different size purple carrots and Lactobacillus Plantarum on the properties of fermented shalgam (Şalgam). Turk. J. Agric. Food Sci. Technol. 9, 1759–1766 (2021).

Google Scholar

Santos, G., Nunes, T. P., Silva, M. A. A. P., Rosenthal, A. & Pagani, A. A. C. Development and acceptance of freeze-dried yogurt ‘powder yogurt’. Int. Food Res. J. 25, 1159–1165 (2018).

CAS Google Scholar

Download references

Department of Processing and Food Engineering, Punjab Agricultural University, Ludhiana, India

Preetinder Kaur & Ruchika Zalpouri

Department of Microbiology, Punjab Agricultural University, Ludhiana, India

Ritika Modi & Param Pal Sahota

Department of Vegetable Science, Punjab Agricultural University, Ludhiana, India

Tarsem Singh Dhillon

Department of Mathematics, Statistics and Physics, Punjab Agricultural University, Ludhiana, India

Amrit Kaur

You can also search for this author in PubMed Google Scholar

You can also search for this author in PubMed Google Scholar

You can also search for this author in PubMed Google Scholar

You can also search for this author in PubMed Google Scholar

You can also search for this author in PubMed Google Scholar

You can also search for this author in PubMed Google Scholar

P.K., P.P.S. and T.S.D. helped in conceptualization, provided resources for investigation, supervised and edited the manuscript. R.Z. and R.M. conducted the experiment and wrote the main manuscript text and did the formal analysis. A.K. helped in statistical analysis. All authors reviewed the manuscript.

Correspondence to Ruchika Zalpouri.

The authors declare no competing interests.

Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/.

Reprints and Permissions

Kaur, P., Zalpouri, R., Modi, R. et al. Development and standardization of processing technique for ready-to-use lab fermented Kanji mix using refractance window dried black carrot powder. Sci Rep 13, 185 (2023). https://doi.org/10.1038/s41598-023-27450-5

Download citation

Received: 25 August 2022

Accepted: 02 January 2023

Published: 05 January 2023

DOI: https://doi.org/10.1038/s41598-023-27450-5

Anyone you share the following link with will be able to read this content:

Sorry, a shareable link is not currently available for this article.

Provided by the Springer Nature SharedIt content-sharing initiative

By submitting a comment you agree to abide by our Terms and Community Guidelines. If you find something abusive or that does not comply with our terms or guidelines please flag it as inappropriate.